Lawrenceville GA – HVAC Service, Electricians & Plumbers

Arrived on site for home care inspection. Checked in with customer and also checked thermostat for power and functionality. Went into attic space to where a furnace is. Furnace is 30 years old, doesn’t have flood protection left note and a quote for it. Tested heat, and cooling mode, all heating elements are working. Noticed the gas lines holding onto burners are held onto unit by two metal wires. Recommended replacing furnace sen it is 30 years old, customer declined stating they are moving in a couple months. All cooling elements are working as well. Blower and blower wheel are OK. When looking at the ductwork I had found that the dryer flue vent had been smashed about a foot away from connecting to outdoor. Left a quote for repairs. After that went outside to condenser, condenser is 19 years old. Contactor and capacitor are OK. Contactor looks to have been replaced within the last couple years. Coils are OK. Brand of condenser is unknown. Data tag is to sun-dried to be able to tell

Replace prv in crawlspace to stabilize pressure and protect the water system

Came to do an inspection for a one system. Homeowner decided to become a Homecare member today. Did a maintenance on both systems. Duct design isn’t correct missing 200CFM on return for both units. Dual capacitor for main unit is bad. Found a small leak on the upstairs units. Systems are both cooling but pressures are fair. Cleared out drain lines. Collected payment for Homecare paid upfront for both units. Collected signatures and confirmed email.

Inspection report to do list

HOMECARE MAINTENANCE VIST: Check Ran the heat and cooling. Checked sequence of the operations cycling well. Amps draw. Temperature differentials. Wires connections. Blower motor. Run capacitor 12.5 mfd. pleated filter 16-25-1. Flushed the drain line with 3 gallons of water. No inline or wet switches found. Checked the condenser unit amps draw. Contactor. Run capacitor 45/5 mfd is weak. Refrigerant pressures 410a needs adjustment 2 to 3 lbs to balance the super heat and sub cooling but is not warranty due to possible refrigerant leak. Mrs Taylor agreed for condenser unit deep cleaning. Checked refrigerant charge pressures and readings are low that’s indication of possible refrigerant leak. I performed courtesy leak search for indoor coil And I found the aluminum evaporator coil is leaking refrigerant and can’t be repair needs to be replaced Evap coil. Homeowner is aware of the conditions of the system. Thanks for choosing te certified.

Upon arrival customer stated that outdoor fan on system stopped working and was burning hot, customer turned system off and it has not been on since. Did full evaluation of 20 year old gas furnace and ac/coil, found that outdoor condenser fan motor failed. Contactor very pitted, condenser coils were very dirty, outdoor capacitor is bad. Checked indoor unit, evaporator coil is very rusted, rust is falling into drain line, drain line does not have enough elevation to drain properly. Blower wheel is very dirty, blower motor is pulling high amps. System is a 3.5 ton unit and under supplied on duct work. Spoke with customer about issues with equipment, gave customer estimate for repairs and also recommended updating system. Customer does not want to do any repairs, customer would like to speak with install supervisor about updating system and having an all electric system and also changing water heater to electric as well, called office to schedule appointment for today. System not working

Troubleshoot

Replace meter housing Replace main disconnect Install new grounding rods Install grounding bridge

For this job, I completed a two system homecare maintenance. I tested both units and its functions to ensure that everything was working. I inspected the blower and burners and cleared the drain line with 2 gallons of water and vinegar. Then proceeded to inspect the outdoor unit and measure all electrical components as well as get pressure readings. I explained all my findings to the customer as well as provided estimates. Customer filter sizes : Upstairs (413 April aire ) Main level ( 16x25x1)

Replaced 12 inch flex and installed two wet switches

For this job, we did a full system install, transition to the supply

Install ev charger in new home

Inspected Armstrong AC and found faulty contactor and dual cap. Condensor fan motor over amping. System is r22. Highly recommended customer invest in new AC due to age and repair cost. Customer said furnace is not operating. Inspected furnace and found restricted combustion motor. Cleared motor and confirmed furnace operation. Customer wants to speak with sales tech to upgrade AC and coil only. System is not cooling at this time.

Performed 1 system diagnostic for main level unit. Found pan full of water, pump continuously running, evap coil rusted, no charge left on unit, condenser is crooked on the pad, dual cap is fail, dirty blower wheel, no te flood protection, blower motor drawing high amps. System is non operational. Based on our findings today, it might be time to think about getting a brand new system.

Replacing switch in the kitchen to a stack switch and running switch leg down under the sink for a garbage disposal receptacle.

Cut out old ice maker box that have an old gate valve that is leaking and replace with a new ice maker box. Remove old rusted away pop up assembly for a sink in the upstairs bathroom and replace with a new one.

Water heater install and two toilet rebuild

For this job, we did a full system install, new metal flue to take out a T and put a Wye in, new drain line up to exit point, a supply transition, media cleaner

Returned today to rejuvenate the upstairs blower motor. Installed a wet switch in attic. Flushed the drain. Two deep cleaning on the condenser coils outside. Checked the refrigerant pressures 410A. All systems are running fine at this time. However my recommendations are about: 1) The main level requires a wet switch to avert the water damage. 2) To upgrade the old condensate pump. For an excellent operation. Thank you for choosing T. E Certified. We truly appreciate your business

Cleared blockage in kitchen sink with flexshaft cable

Replace faulty arc fault breaker

Removed 45 gallons of water from duct and return plenum.

Upon arrival contractor need system service and brought up to code… tech replaced all bad parts at indoor and outdoor unit. Cleaned outdoor coils, added suction line insulation and removed tape at flue pipe added a condensation pump… will need to return to add a 6 inch duct run at supply plenum…

Replace flood with ring

Perform one system diagnostic for upstairs system. System is 19 years old R 22 control board with charge marks on it filled capacitor for inside and outside unit dirty blow wheel dirty condenser. Customer opted for replacement quote instead of any repairs. Customer is also interested in replacing main system due to it be manufactured in 1987. Have an installed supervisor scheduled for Friday, May 29 8 to 10. Customer would like to install supervisor arriving as close to eight as possible. Based on our findings today, it might be time to think about getting a brand new system.